Rear axle trailing-arm bearings
usually 100,000–220,000 km · High risk
Signs: Rear wheels lean in at the top, uneven tyre wear, knocking
Fix: Rebuild or replace the rear axle
€300–900
Common faults, service intervals and costs
Peugeot 206+ / 206 SW
2002–2012
4
engines covered
17
known faults
11
official recalls
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
The Peugeot 206+ / 206 SW was built from 2002 to 2012.
For this generation we cover 4 engines and 17 known faults, each with the mileage range where it usually appears.
The most expensive known risk is Turbo failure (oil starvation, 16v): it usually appears at 80,000–200,000 km and costs €700–1,600 to fix.
Engines
| Engine | Fuel | Timing drive | Oil |
|---|---|---|---|
| 1.1 / 1.4 / 1.6 8v & 16v (PSA TU / ET3 / EC5) | Petrol | Belt · 120,000 km / every 60 mo | 5W-40 / 10W-40 · PSA B71 2296 / B71 2300 · ~3.25 L · every 15,000 km |
| 1.4 HDi / TDCi (DV4) | Diesel | Belt · 150,000 km / every 96 mo | 5W-30 / 5W-40 · PSA B71 2290 / B71 2296 · ~3.75 L · every 15,000 km |
| 2.0 HDi / TDCi / BlueHDi (DW10) | Diesel | Belt · 150,000 km / every 96 mo | 5W-30 · PSA B71 2290 / Ford WSS-M2C913-C / 934-B · ~4.25–5.5 L · every 15,000 km |
| 1.5 / 1.6 HDi / TDCi / e-HDi (DV6, 8v / 16v) | Diesel | Belt · 150,000 km / every 96 mo | 5W-30 · PSA B71 2290 / Ford WSS-M2C913-C · ~3.75 L · every 15,000 km |
Faults typical of this model
BSI / electrical faults
usually 100,000–250,000 km · Wear part
Signs: Random warnings, wipers / lights act up
Fix: Diagnose, update or repair BSI
€100–500
Faults by engine
1.1 / 1.4 / 1.6 8v & 16v (PSA TU / ET3 / EC5)
Ignition coil pack
usually 80,000–160,000 km · Medium risk
Signs: Misfire, flashing engine light
Fix: Replace coil pack
€60–200
Thermostat housing / coolant leaks
usually 100,000–200,000 km · Wear part
Signs: Coolant loss, overheating
Fix: Replace housing / hoses
€80–250
Idle control valve / throttle body
usually 100,000–200,000 km · Wear part
Signs: Hunting idle, stalling
Fix: Clean or replace
€60–200
Head gasket (1.6 16v, overheating)
usually 150,000–250,000 km · Wear part
engine codes: NFU, NFV, NFZ, NFX, NFS, NFR
Signs: Coolant loss, white smoke
Fix: Replace head gasket
€400–900
1.4 HDi / TDCi (DV4)
Injectors / high-pressure pump (Siemens)
usually 150,000–250,000 km · Medium risk
Signs: Hard start, smoke
Fix: Test and replace
€400–1,200
Turbo oil feed / seals
usually 150,000–250,000 km · Medium risk
Signs: Smoke, oil use
Fix: Service the turbo
€400–900
EGR valve
usually 120,000–220,000 km · Wear part
Signs: Rough idle
Fix: Clean
€100–300
2.0 HDi / TDCi / BlueHDi (DW10)
Injectors / injector seals
usually 150,000–250,000 km · Medium risk
Signs: Smoke, knocking, hard start
Fix: Replace seals / injectors
€300–1,500
EGR valve / swirl flap actuator
usually 120,000–220,000 km · Medium risk
Signs: Limp mode
Fix: Clean or replace
€200–700
Turbo actuator / vanes
usually 150,000–250,000 km · Medium risk
Signs: Overboost / underboost
Fix: Clean or replace
€300–1,000
1.5 / 1.6 HDi / TDCi / e-HDi (DV6, 8v / 16v)
Turbo failure (oil starvation, 16v)
usually 80,000–200,000 km · High risk
model years 2004–2011 only
Signs: Whistle, blue smoke, oil loss — carbon blocks the oil feed filter
Fix: Replace turbo, oil feed pipe with filter, clean the sump
€700–1,600
Injector copper seal leak → carbon build-up
usually 80,000–200,000 km · High risk
Signs: Ticking, diesel / soot smell, carbon around injectors
Fix: Replace seals early; remove carbon
€200–900
EGR valve / cooler
usually 100,000–200,000 km · Medium risk
Signs: Limp mode, power loss
Fix: Clean or replace
€200–600
Gearboxes
Manual
Clutch wear
usually 120,000–200,000 km · Medium risk
Signs: Slipping, high bite point
Fix: Replace clutch kit
€500–900
AL4 / AT8 (4-speed automatic)
AL4 solenoids / pressure regulator
usually 80,000–180,000 km · High risk
Signs: Gearbox warning, stuck in 3rd, harsh shifts
Fix: Replace solenoids / pressure sensor; fluid change
€300–1,500
Scheduled service
Intervals and typical prices for the 1.1 / 1.4 / 1.6 8v & 16v (PSA TU / ET3 / EC5) engine. Other engines differ in oil, timing drive and some filters; the app gives the exact plan.
| Item | Interval | Typical price |
|---|---|---|
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Spark plugsIgnition | every 60,000 km or every 48 months | €50–160 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Timing belt kit + water pumpEngine | every 120,000 km or every 60 months | €450–900 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Manual gearbox oilTransmission | every 150,000 km | €60–130 |
| Front brake padsBrakes | usually at 30,000–60,000 km | €60–150 |
| Front brake discs + padsBrakes | usually at 60,000–120,000 km | €150–320 |
| Rear brake padsBrakes | usually at 50,000–90,000 km | €50–130 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
Official recalls
Recalls the manufacturer published in the United Kingdom for this model (11). The same recalls usually apply across Europe. Ask an authorised dealer to check by VIN whether your car is affected and whether the work has been done.
- Engine / loss of power Engine may fail13/11/2012 · R/2012/135
- Fuel system Fuel pipe may leak26/11/2008 · R/2008/182
- Visibility Windscreen wipers may fail27/10/2008 · R/2008/155
- Seat belt Front right hand seatbelt fixing bolt may fail22/11/2006 · R/2006/212
- Fuel system Possible seepage on the diesel fuel return pipe11/04/2005 · R/2005/047
- Electronics / software Possibility that the starter motor wiring loom is incorrectly positioned13/09/2004 · R/2004/167
- Brakes / ABS / ESP Possibility of erratic operation of the motorized throttle body14/05/2004 · R/2004/087
- Doors / locks / lids Possibility that the rear spoiler may detach07/05/2004 · R/2004/082
The other recalls (3) are listed in the app.
Common questions
Does the Peugeot 206+ / 206 SW have a timing chain or a timing belt?
1.1 / 1.4 / 1.6 8v & 16v (PSA TU / ET3 / EC5): belt · 120,000 km / every 60 mo; 1.4 HDi / TDCi (DV4): belt · 150,000 km / every 96 mo; 2.0 HDi / TDCi / BlueHDi (DW10): belt · 150,000 km / every 96 mo; 1.5 / 1.6 HDi / TDCi / e-HDi (DV6, 8v / 16v): belt · 150,000 km / every 96 mo.
What are the known problems with the Peugeot 206+ / 206 SW?
The faults with the highest risk: turbo failure (oil starvation, 16v) (80,000–200,000 km, €700–1,600); AL4 solenoids / pressure regulator (80,000–180,000 km, €300–1,500); rear axle trailing-arm bearings (100,000–220,000 km, €300–900); injector copper seal leak → carbon build-up (80,000–200,000 km, €200–900). The full list by engine is on this page.
What should you check when buying a used Peugeot 206+ / 206 SW?
Before you buy, ask an authorised dealer to check by VIN that the recalls have been done (11 have been published for this model). If the engine has a timing belt, ask for the invoice for its replacement: with no proof, assume it has not been done. On the test drive, watch for these signs: whistle, blue smoke, oil loss — carbon blocks the oil feed filter; gearbox warning, stuck in 3rd, harsh shifts. The full checklist is in the guide to buying a used car.
Other generations
Peugeot 106 1991–2003Peugeot 107 / 108 2005–2021Peugeot 206 1998–2012Peugeot 207 2006–2014Peugeot 208 I 2012–2019Peugeot 2008 I 2013–2019Peugeot 208 II 2019–Peugeot 2008 II 2019–Peugeot 301 2012–2017Peugeot 307 2001–2008Peugeot 308 I 2007–2013Peugeot 308 SW / RCZ 2008–2015Peugeot 308 II 2013–2021Peugeot 308 III 2021–Peugeot 3008 I 2009–2016Peugeot 3008 II 2016–2023Peugeot 5008 I 2009–2017Peugeot 5008 II 2017–Peugeot 406 1995–2004Peugeot 407 2004–2011Peugeot 508 I 2010–2018Peugeot 508 II 2018–Peugeot 607 1999–2010Peugeot 807 2002–2014Peugeot 4007 2007–2012Peugeot 4008 2012–2017Peugeot 205 1983–1998Peugeot 306 1993–2002Peugeot 3008 III 2023–
Models with the same engines
These models share engines with this car, so they share some of its faults too.
Ford Fiesta VI (Mk6/Mk7) 2008–2017Ford Focus III 2011–2018Ford Focus II 2004–2011Ford Kuga II 2012–2019Ford Fiesta V 2002–2008Volvo S40 / V50 2004–2012Volvo V70 III 2007–2016Citroën C4 II 2010–2018
Other Peugeot models
Peugeot Boxer III 2006–2014Peugeot Expert II 2007–2016Peugeot Partner I 1996–2008Peugeot Partner II / Tepee 2008–2018
Sources and notes
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Dutch tests: RDW Open Data (CC0). Engine versions: EEA, monitoring of CO₂ emissions from new passenger cars (CC BY 4.0, DG CLIMA). Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles.
Updated 08/10/2026