Petrol · 2010–2019
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
All about the Ford C-Max / Grand C-MaxAll about the 1.0 EcoBoost / 1.0 Ti-VCT (Fox) engine
The 1.0 EcoBoost / 1.0 Ti-VCT (Fox) engine was fitted to the Ford C-Max / Grand C-Max (2010–2019). In the EU that is 20.0 % of all new cars of this generation.
Versions: 1.0 125 hp, 1.0.
The most expensive known risk is door latch failure (recall): it usually appears at 0–200,000 km and costs €0–250 to fix.
✓ The faults of this engine were checked against sources (10/2026). Each item has at least two independent sources or an official recall or parts-maker technical note.
Signs: Oil pressure warning, often just before power loss; rubber bits in the oil or filter; sometimes sudden failure with no warning
Fix: Replace the belt by 160,000 km / 6 years (Ford's 2026 interval), use oil to Ford spec, look for belt debris at every oil change, and stop at once if the oil light comes on
Signs: Oil pressure warning and engine light, rattle from the lower engine, loss of power; brake servo can get weaker
Fix: Stop the engine at once; fit the revised belt and bolted tensioner, and renew the oil pump belt at every timing belt job
Signs: Coolant loss, steam, temperature warning; driving on can blow the head gasket
Fix: Check by VIN that Ford's 2015 service action was done, replace the hose, and after any overheating test the head gasket
Signs: Coolant level drops with no visible leak, white exhaust smoke, rough running or misfire, later overheating
Fix: Pressure-test the cooling system; if there is no external leak, inspect the integrated exhaust manifold ports for cracks and replace the cylinder head
Signs: Door won't latch or opens while driving
Fix: Check recall; replace latch
Signs: Freezes, Bluetooth drops
Fix: Software update
Signs: Slipping, high bite point
Fix: Replace clutch kit
Signs: Rattle at idle, vibration pulling away
Fix: Replace with clutch
Signs: Shudder or judder when pulling away, slipping, delayed take-off, rough 1-2 shifts, gearbox warning
Fix: Replace the double clutch together with the input-shaft seals (and check the rear crankshaft seal), then run the clutch adaptations; software update if available
Signs: Gearbox warning, car suddenly loses drive or will not engage a gear, intermittent no-start in gear, faults such as P0606
Fix: First test the battery, the gearbox ground connection and the TCM plug / harness; if the module is faulty, replace and program it and run the relearn procedures
Signs: Gearbox warning with a clutch-actuator code, harsh or no engagement of odd or even gears, limp mode
Fix: Swap the two actuator motors to see if the fault follows the motor; replace the faulty actuator and run the clutch adaptation
Signs: Rough shifts when the fluid is old
Fix: Fluid change every 60,000 km
Signs: Delayed or harsh shifts
Fix: Fluid service, repair
Typical routine maintenance cost for 100,000 km: €2,900–6,350. Sum of the services and wear parts in the plan above (about 15,000 km a year, independent workshop), without faults.
Intervals and typical prices for the Ford C-Max / Grand C-Max with the 1.0 EcoBoost / 1.0 Ti-VCT (Fox) engine. The app gives the exact plan for your mileage.
| Item | Interval | Typical price |
|---|---|---|
| Timing belt kit + water pump (belt runs in oil)Engine | every 160,000 km or every 72 months | €700–1,400 |
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Spark plugsIgnition | every 60,000 km or every 48 months | €50–160 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Manual gearbox oilTransmission | every 150,000 km | €60–130 |
| Front brake padsBrakes | usually at 30,000–60,000 km | €60–150 |
| Front brake discs + padsBrakes | usually at 60,000–120,000 km | €150–320 |
| Rear brake padsBrakes | usually at 50,000–90,000 km | €50–130 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
| Version | Share | Years | CO₂ | Fuel use |
|---|---|---|---|---|
| 1.0 Petrol999 cm³ · 92 kW (125 hp) | 11.9 % | 2012–2019 | 143 g/km | — |
| 1.0 Petrol999 cm³ | 4.8 % | 2012–2019 | 138 g/km | — |
Source: European Environment Agency (EEA), monitoring of CO₂ emissions from new passenger cars, CC BY 4.0. CO₂ and fuel use are official type-approval values (WLTP from 2021), not real-world consumption.
Recalls the manufacturer published in the United Kingdom for this model (10). The same recalls usually apply across Europe. Ask an authorised dealer to check by VIN whether your car is affected and whether the work has been done.
The faults with the highest risk: door latch failure (recall) (0–200,000 km, €0–250).
Wet belt · 160,000 km / every 72 mo.
5W-20 · Ford WSS-M2C948-B · ~4.1 L · every 15,000 km.
1.5 / 1.6 HDi / TDCi / e-HDi (DV6, 8v / 16v)2.0 HDi / TDCi / BlueHDi (DW10)1.5 / 1.6 EcoBoost (4-cyl)1.25 / 1.4 / 1.5 / 1.6 Duratec / Ti-VCT (Ford Sigma)
Ford Fiesta VI (Mk6/Mk7) 2008–2017Ford Focus III 2011–2018Ford Fiesta VII (Mk8) 2017–2023Ford Focus IV 2018–2025Ford Tourneo / Transit Connect II 2013–2022Ford EcoSport 2013–2022Ford Puma 2019–Ford B-Max 2012–2017
Main sources for the faults of this engine:
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Dutch tests: RDW Open Data (CC0). Engine versions: EEA, monitoring of CO₂ emissions from new passenger cars (CC BY 4.0, DG CLIMA). Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles. How we check the data →
Updated 29/10/2026