Diesel · 2013–2019
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
All about the Peugeot 2008 1All about the 1.5 / 1.6 HDi / TDCi / e-HDi (DV6, 8v / 16v) engine
The 1.6 HDi / TDCi / e-HDi (DV6, 8v / 16v) engine was fitted to the Peugeot 2008 1 (2013–2019). In the EU that is 23.3 % of all new cars of this generation.
Versions: 1.6 99 hp, 1.6 92 hp, 1.6 120 hp, 1.6, 1.6 114 hp.
The most expensive known risk is DPF clogging; Eolys additive runs low (additive systems): it usually appears at 80,000–200,000 km and costs €100–1,500 to fix.
✓ The faults of this engine were checked against sources (10/2026). Each item has at least two independent sources or an official recall or parts-maker technical note.
Signs: Knocking at low revs, jerking in the lower gears, hard cold starts, injector fault codes
Fix: Read the injector corrections and do a return-flow test; recode or replace the faulty injectors
Signs: Jerking, black smoke, power loss or limp mode, EGR fault codes; mostly on cars used for short trips
Fix: Clean or replace the EGR valve; cleaning often helps only for a while
Signs: DPF or additive-level warning, limp mode after long periods of city driving
Fix: Refill the additive and reset the counter, check the pressure sensor, force a regeneration; clean or replace the DPF if it is full
Signs: Screen lags or freezes, phone will not pair or drops the connection, music playlists cannot be accessed.
Fix: Reset the unit and install the latest software at a Peugeot dealer; replace the head unit only if faults persist.
Signs: Clunks or vibration from the front end and vague steering; in the worst case a broken bolt affects steering control.
Fix: Check by VIN with a Peugeot dealer that the bolt-replacement recall was done; free of charge.
Signs: Usually no warning; ABS and ESP may not intervene correctly in an emergency stop or swerve.
Fix: Check by VIN with a Peugeot dealer that the hydraulic unit was replaced under the 2016 recall; free of charge.
Signs: Starter keeps running or smells hot; in extreme cases the starter overheats and can start a fire.
Fix: Check by VIN with a Peugeot dealer that the starter recall was done; free of charge.
Signs: Rust on the subframe, knocks or a changed steering feel; a cracked subframe can cause loss of control.
Fix: Check by VIN with a Peugeot dealer (recall JSB) and inspect the subframe for rust; repair under recall is free.
Signs: Discs worn or ridged at inspection sooner than expected; vibration or noise when braking; brake efficiency marked down on older cars.
Fix: Measure disc thickness at every service and budget for discs with every second set of pads.
Signs: Dead bulbs or lamps, often found only at the technical inspection.
Fix: Check all lamps before inspection; replace bulbs and inspect bulb holders and connectors for corrosion.
Signs: Temperature rises in traffic, fan does not run or runs constantly, A/C cools poorly at standstill.
Fix: Test the fan motor, its control module/resistor and connector; replace the faulty part before the engine overheats.
Signs: Torn boot with grease spray, clicking when turning under load; found at inspection.
Fix: Replace a torn boot early; replace the joint or drive shaft if it already clicks.
Signs: Louder or rattling exhaust, blowing noise under the car, inspection failure for leaks or loose mountings.
Fix: Replace the rusted section or flex pipe and check the rubber hangers.
Signs: Slipping, high bite point
Fix: Replace clutch kit
Signs: Won't select a gear, 'gearbox fault', jerky shifts
Fix: Repair or replace the actuator; clutch re-learn
Signs: Slipping, harsh engagement
Fix: Replace clutch + re-learn
Signs: Jerks or clunks when slowing down or in town traffic, hesitation when pulling away, flare or slip when cold
Fix: Ask for the latest gearbox software and an adaptation reset; check the oil level and condition
Signs: Harsh or slipping shifts that get worse over time, dark burnt-smelling fluid, gearbox warning or limp mode
Fix: Change the fluid (several partial changes or a machine change with the correct Aisin / PSA fluid); if shifts stay bad, repair the valve body / solenoids or overhaul the gearbox
Typical routine maintenance cost for 100,000 km: €2,400–5,750. Sum of the services and wear parts in the plan above (about 15,000 km a year, independent workshop), without faults.
Intervals and typical prices for the Peugeot 2008 1 with the 1.6 HDi / TDCi / e-HDi (DV6, 8v / 16v) engine. The app gives the exact plan for your mileage.
| Item | Interval | Typical price |
|---|---|---|
| DPF health check (soot / ash load)Emissions | every 20,000 km | €0–60 |
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Fuel filterFuel | every 30,000 km or every 24 months | €40–110 |
| Glow plugsEngine | every 100,000 km | €120–300 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Timing belt kit + water pumpEngine | every 150,000 km or every 96 months | €450–900 |
| Manual gearbox oilTransmission | every 150,000 km | €60–130 |
| Front brake padsBrakes | usually at 30,000–60,000 km | €60–150 |
| Front brake discs + padsBrakes | usually at 60,000–120,000 km | €150–320 |
| Rear brake padsBrakes | usually at 50,000–90,000 km | €50–130 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
| Version | Share | Years | CO₂ | Fuel use |
|---|---|---|---|---|
| 1.6 Diesel1,560 cm³ · 73 kW (99 hp) | 13.4 % | 2015–2018 | 94 g/km | — |
| 1.6 Diesel1,560 cm³ · 68 kW (92 hp) | 10.8 % | 2013–2017 | 103 g/km | — |
| 1.6 Diesel1,560 cm³ · 88 kW (120 hp) | 6.8 % | 2014–2018 | 96 g/km | — |
| 1.6 Diesel1,560 cm³ | 6.0 % | 2013–2018 | 96 g/km | — |
| 1.6 Diesel1,560 cm³ · 84 kW (114 hp) | 4.2 % | 2013–2017 | 105 g/km | — |
Source: European Environment Agency (EEA), monitoring of CO₂ emissions from new passenger cars, CC BY 4.0. CO₂ and fuel use are official type-approval values (WLTP from 2021), not real-world consumption.
Recalls the manufacturer published in the United Kingdom for this model (25). The same recalls usually apply across Europe. Ask an authorised dealer to check by VIN whether your car is affected and whether the work has been done.
The faults with the highest risk: DPF clogging; Eolys additive runs low (additive systems) (80,000–200,000 km, €100–1,500); EGR valve sooting (80,000–200,000 km, €100–600); radiator cooling fan fails (60,000–200,000 km, €150–450).
Belt · 150,000 km / every 96 mo.
5W-30 · PSA B71 2290 / Ford WSS-M2C913-C · ~3.75 L · every 15,000 km.
1.2 PureTech (EB)1.6 BlueHDi (DV6FC)1.4 / 1.6 VTi (EP3 / EP6, also MINI N12 / N16)
Ford Fiesta VI (Mk6/Mk7) 2008–2017Ford Focus III 2011–2018Ford Focus II 2004–2011Peugeot 208 I 2012–2019Ford Kuga II 2012–2019Peugeot 207 2006–2014Volvo S60 / V60 I 2010–2018Volvo S40 / V50 2004–2012Volvo V70 III 2007–2016Citroën C4 II 2010–2018Volvo V40 2012–2019Ford C-Max / Grand C-Max 2010–2019
Main sources for the faults of this engine:
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Dutch tests: RDW Open Data (CC0). Engine versions: EEA, monitoring of CO₂ emissions from new passenger cars (CC BY 4.0, DG CLIMA). Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles. How we check the data →
Updated 29/10/2026