EGR valve / DPF
usually 100,000–200,000 km · Medium risk
Signs: Limp mode
Fix: Clean or replace
€300–1,500
Common faults, service intervals and costs
Mercedes-Benz Vito (W447)
2014–now
3
engines covered
10
known faults
50,678
roadworthiness tests in the statistics
77
official recalls
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
The Mercedes-Benz Vito (W447) has been built since 2014.
For this generation we cover 3 engines and 10 known faults, each with the mileage range where it usually appears.
The most expensive known risk is Piezo injectors (2009–2011): it usually appears at 60,000–140,000 km and costs €1,000–2,500 to fix.
In UK roadworthiness tests in 2024, at 100–150 thousand km this model most often failed on: lights, wipers and visibility (12.1 %), brakes (8.6 %), tyres and wheels (7.8 %). It fails more often than an average car of the same age and mileage on: brakes, suspension, exhaust, emissions and leaks. It fails less often than average on: body and corrosion.
Engines
| Engine | Fuel | Timing drive | Oil |
|---|---|---|---|
| 1.6 dCi (Renault-Nissan R9M, also Mercedes OM626) | Diesel | Chain | 5W-30 / 0W-30 · Renault RN0720 · ~5.5 L · every 15,000 km |
| 2.1 CDI (Mercedes OM651) | Diesel | Chain | 5W-30 · MB 229.51 / 229.52 · ~6.5 L · every 15,000 km |
| 2.0 d (Mercedes OM654) | Diesel | Chain | 0W-20 / 5W-30 · MB 229.52 / 229.71 · ~6.5 L · every 15,000 km |
Faults by engine
1.6 dCi (Renault-Nissan R9M, also Mercedes OM626)
Turbo actuator / boost pressure
usually 120,000–220,000 km · Medium risk
Signs: Low power, limp mode
Fix: Replace actuator
€300–900
Timing chain noise / stretch (vans)
usually 120,000–220,000 km · Medium risk
Signs: Rattle at idle or on start — Trafic / Vivaro / Talento
Fix: Replace the chain kit
€900–1,800
2.1 CDI (Mercedes OM651)
Piezo injectors (2009–2011)
usually 60,000–140,000 km · High risk
Signs: Rough running, knocking, no-start
Fix: Replace injectors (check campaign)
€1,000–2,500
Timing chain stretch
usually 200,000–280,000 km · Medium risk
Signs: Correlation codes, rattle
Fix: Replace chain
€1,200–2,200
EGR / DPF
usually 150,000–220,000 km · Medium risk
Signs: Limp mode, DPF light
Fix: Clean or replace
€300–1,500
2.0 d (Mercedes OM654)
AdBlue / SCR faults
usually 100,000–180,000 km · Medium risk
Signs: AdBlue warning
Fix: Replace NOx sensor or doser
€300–1,000
Gearboxes
Manual
Clutch wear
usually 120,000–200,000 km · Medium risk
Signs: Slipping, high bite point
Fix: Replace clutch kit
€500–900
Dual-mass flywheel
usually 150,000–220,000 km · Medium risk
Signs: Rattle at idle, vibration pulling away
Fix: Replace with clutch
€700–1,400
5G / 7G / 9G-Tronic
Conductor plate / speed sensor (5G / 7G-Tronic)
usually 100,000–220,000 km · Medium risk
Signs: Stuck in gear, limp mode, harsh shifts
Fix: Replace the conductor plate; fluid every 60–100,000 km
€500–1,500
Scheduled service
Intervals and typical prices for the 1.6 dCi (Renault-Nissan R9M, also Mercedes OM626) engine. Other engines differ in oil, timing drive and some filters; the app gives the exact plan.
| Item | Interval | Typical price |
|---|---|---|
| DPF health check (soot / ash load)Emissions | every 20,000 km | €0–60 |
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Fuel filterFuel | every 30,000 km or every 24 months | €40–110 |
| Glow plugsEngine | every 100,000 km | €120–300 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Timing chain inspection (listen on cold start)Engine | every 150,000 km | €0–120 |
| Manual gearbox oilTransmission | every 150,000 km | €60–130 |
| Front brake padsBrakes | usually at 30,000–60,000 km | €60–150 |
| Front brake discs + padsBrakes | usually at 60,000–120,000 km | €150–320 |
| Rear brake padsBrakes | usually at 50,000–90,000 km | €50–130 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
Roadworthiness tests by mileage
Share of tests in the United Kingdom (DVSA MOT, 2024) that this model failed because of each system. Bold red means more often and green less often than an average car of the same age and mileage. Sample: 50,678 tests.
| thousand km | 0–50 | 50–100 | 100–150 | 150–200 | 200–250 | 250+ |
|---|---|---|---|---|---|---|
| Brakes | 3.1 % | 6.9 % | 8.6 % | 10.4 % | 11.6 % | 11.1 % |
| Suspension | 0.8 % | 3.9 % | 7.1 % | 8.6 % | 9.8 % | 10.1 % |
| Steering | 0.1 % | 0.2 % | 0.2 % | 0.4 % | 0.4 % | 0.9 % |
| Tyres and wheels | 4.6 % | 6.6 % | 7.8 % | 7.7 % | 7.2 % | 6.5 % |
| Lights, wipers and visibility | 8.1 % | 11.2 % | 12.1 % | 13.8 % | 13.6 % | 12.9 % |
| Body and corrosion | 0.4 % | 0.7 % | 1.1 % | 1.3 % | 1.6 % | 1.8 % |
| Exhaust, emissions and leaks | 1.2 % | 2.9 % | 4.4 % | 5.6 % | 6.0 % | 6.7 % |
Official recalls
Recalls the manufacturer published in the United Kingdom for this model (77). The same recalls usually apply across Europe. Ask an authorised dealer to check by VIN whether your car is affected and whether the work has been done.
- Engine / loss of power Update software of control units15/05/2025 · R/2025/116
- Steering SRPC2420 – Fastening of Steering Wheel Height Adjustment29/11/2024 · R/2024/475
- Fuel system On affected vehicles the routing of the fuel filter drainpipe might not meet specifications. The drainpipe could come into contact with the underbody and become damaged leading to a diesel leak.13/02/2023 · R/2023/012
- Fuel system On affected vehicles the routing of the fuel filter drainpipe might not meet specifications. The drainpipe could come into contact with the underbody and become damaged leading to a diesel leak.27/01/2023 · R/2023/011
- Electronics / software The routing of the interior wiring harness in the area of the centre console might not meet specifications29/11/2022 · R/2022/335
- Visibility The rear view camera could display frozen images due to a defect in a memory chip28/09/2022 · R/2022/271
- Gearbox On certain vehicles the gear recognition sensor could under certain circumstances while shifting to the reverse gear underrun a certain limit parameter and therefore transmit incorrect particular sensor signals08/08/2022 · R/2022/233
- Airbag The takata driver's air bag might not deploy as specified12/07/2022 · R/2022/161
The other recalls (69) are listed in the app.
Other generations
Sources and notes
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles.
Updated 07/10/2026