Diesel · 2004–2012
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
All about the Lancia MusaAll about the 1.3 MultiJet / CDTI / DDiS / TDCi engine
The 1.2 MultiJet / CDTI / DDiS / TDCi engine was fitted to the Lancia Musa (2004–2012). In the EU that is 44.0 % of all new cars of this generation.
Versions: 1.2 95 hp, 1.2.
The most expensive known risk is timing chain stretch and tensioner wear: it usually appears at 100,000–200,000 km and costs €800–1,300 to fix.
✓ The faults of this engine were checked against sources (10/2026). Each item has at least two independent sources or an official recall or parts-maker technical note.
Signs: Metallic rattle from the chain side on cold start, crank/cam correlation fault code, engine light
Fix: Measure the crank/cam deviation with a diagnostic tool; replace the chain kit with tensioner and guides before the chain jumps
Signs: Hard starting, rough or knocking idle when cold, power loss, higher fuel use, sometimes limp mode
Fix: Read per-cylinder correction values and back-leak; repair or replace only the faulty injector and renew its seal
Signs: Engine light, rough idle, hesitation, power loss or limp mode; worse with short trips
Fix: Check EGR movement in live data; clean or replace the valve
Signs: Boost fault codes, power loss, limp mode, sometimes whistling or smoke
Fix: Check boost control and charge-air hoses for leaks first; free or replace the actuator, replace the turbo only if it is worn
Signs: Hard starting in cold weather, smoke after a cold start, glow plug warning light
Fix: Test the plugs and the control unit; replace faulty parts (seized plugs may need extraction)
Signs: Heavy steering, EPS warning
Fix: Repair or replace the column / sensor
Signs: Knocks over bumps
Fix: Replace parts
Signs: Slipping, high bite point
Fix: Replace clutch kit
Signs: Longer and rougher shifts, pump runs often or for long, gears drop out while driving, gearbox warning and the car stays in neutral
Fix: Check the hydraulic pressure and fluid level; replace the pressure accumulator first if it has lost its charge, otherwise repair or replace the pump / power unit and bleed the system
Signs: Flashing gear display, delayed or skipped gears, fluid loss from the actuator, gear-sensor or lever-switch fault codes
Fix: Find the leak; reseal the actuator (selector rod O-rings), clean or replace the position sensor, top up with the approved hydraulic fluid and run the calibration
Signs: Jerky or juddering pull-away and upshifts, clutch slip, high clutch wear index in diagnostics
Fix: Read the clutch wear index and adaptation values; replace the clutch if outside the range, then reset the wear index and re-learn the kiss point
Typical routine maintenance cost for 100,000 km: €2,400–5,450. Sum of the services and wear parts in the plan above (about 15,000 km a year, independent workshop), without faults.
Intervals and typical prices for the Lancia Musa with the 1.2 MultiJet / CDTI / DDiS / TDCi engine. The app gives the exact plan for your mileage.
| Item | Interval | Typical price |
|---|---|---|
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Fuel filterFuel | every 30,000 km or every 24 months | €40–110 |
| Glow plugsEngine | every 100,000 km | €120–300 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Timing chain inspection (listen on cold start)Engine | every 150,000 km | €0–120 |
| Manual gearbox oilTransmission | every 150,000 km | €60–130 |
| Front brake padsBrakes | usually at 30,000–60,000 km | €60–150 |
| Front brake discs + padsBrakes | usually at 60,000–120,000 km | €150–320 |
| Rear brake padsBrakes | usually at 50,000–90,000 km | €50–130 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
| Version | Share | Years | CO₂ | Fuel use |
|---|---|---|---|---|
| 1.2 Diesel1,248 cm³ · 70 kW (95 hp) | 23.6 % | 2011–2012 | — | — |
| 1.2 Diesel1,248 cm³ | 19.6 % | 2010–2012 | — | — |
Source: European Environment Agency (EEA), monitoring of CO₂ emissions from new passenger cars, CC BY 4.0. CO₂ and fuel use are official type-approval values (WLTP from 2021), not real-world consumption.
The faults with the highest risk: timing chain stretch and tensioner wear (100,000–200,000 km, €800–1,300); turbo variable vanes or actuator sticking (100,000–200,000 km, €150–1,300); injector faults or leaking injector seals (80,000–200,000 km, €200–1,200); electric power steering column (Dualdrive) (80,000–200,000 km, €200–700).
Chain.
5W-30 / 5W-40 · Fiat 9.55535-S1 / dexos2 · ~3.2–3.9 L · every 15,000 km.
1.4 8v & 16v FIRE1.9 JTD / MultiJet / CDTI / TiD (Fiat 1.9 8v / 16v)
Opel Corsa D 2006–2014Opel Corsa E 2014–2019Fiat Grande Punto / Punto 2005–2018Fiat Panda II 2003–2012Fiat 500X 2014–Alfa Romeo MiTo 2008–2018Fiat 500L 2012–2022Fiat Tipo 2015–Fiat Fiorino / Qubo 2008–
Main sources for the faults of this engine:
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Dutch tests: RDW Open Data (CC0). Engine versions: EEA, monitoring of CO₂ emissions from new passenger cars (CC BY 4.0, DG CLIMA). Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles. How we check the data →
Updated 29/10/2026