Diesel · 2018–2025
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
All about the Ford Focus 4All about the 1.5 BlueHDi / EcoBlue (DV5R) engine
The 1.5 BlueHDi / EcoBlue (DV5R) engine was fitted to the Ford Focus 4 (2018–2025). In the EU that is 26.6 % of all new cars of this generation.
Versions: 1.5 120 hp, 1.5 116 hp.
The most expensive known risk is adBlue (SCR): tank-pump unit or dosing injector fails: it usually appears at 60,000–180,000 km and costs €250–1,500 to fix.
✓ The faults of this engine were checked against sources (10/2026). Each item has at least two independent sources or an official recall or parts-maker technical note.
Signs: Rattle from the top of the engine, timing fault codes; it can also snap without warning and stop the engine
Fix: Check recall status by VIN (Peugeot MXL, Citroën / DS NY5); the dealer fits the reinforced 8 mm chain free of charge
Signs: AdBlue or emissions warning, countdown to no-start, engine light
Fix: Diagnose first: the pump is built into the tank and is replaced as one unit; crystals at the injector or the tank vent can sometimes be cleaned
Signs: Rough running, power loss, warning lights, sudden stalling
Fix: Check recall status by VIN; the dealer replaces the water pump kit free of charge
Signs: Scored or lipped discs, vibration or noise when braking, already at the first roadworthiness tests.
Fix: Replace discs and pads per axle; check that the calipers slide freely so the new set does not wear the same way.
Signs: Usually no warning; in the worst case the pedal loses its pivot and braking is reduced.
Fix: Check the VIN for the open recall; the dealer checks the bolt torque or fits an improved pedal free of charge.
Signs: No warning; the child lock can switch itself off from vibration, or on estates a rear door may open when the window is lowered.
Fix: Check the VIN for open recalls; the dealer inspects and replaces the latch spring or rear door lock free of charge.
Signs: Rough idle, warning lights, loss of power or the engine cutting out while driving.
Fix: Check the VIN for the open recall; the dealer inspects the harness, reroutes it and replaces it if damaged, free of charge.
Signs: Start-stop or Auto-Hold not available, warning messages, slow cranking or no start after the car stands for days.
Fix: Test the battery and look for a parasitic drain; fit the correct AGM/EFB battery, register it, and ask for module software updates.
Signs: Screen freezes or goes black, navigation or phone connection drops, unit restarts.
Fix: Install the latest SYNC 3 software (dealer or USB) and do a master reset before replacing any hardware.
Signs: Parking sensor fault message or constant beeping; the camera shows wrong speed limits.
Fix: Clean and test the sensors, replace a failed sensor; update software, and do not rely on the displayed limit.
Signs: No warning for the buckle; the reversing camera image may freeze, stay blank or show distorted.
Fix: Check the VIN for open recalls; the dealer replaces the buckle or updates/replaces camera parts free of charge.
Signs: Headlight misaligned or a front light out; noted at the roadworthiness test.
Fix: Adjust the headlight aim and replace failed bulbs; on LED units check the connector before replacing the module.
Signs: Slipping, high bite point
Fix: Replace clutch kit
Signs: Delayed or harsh shifts
Fix: Fluid service, repair
Typical routine maintenance cost for 100,000 km: €2,450–5,900. Sum of the services and wear parts in the plan above (about 15,000 km a year, independent workshop), without faults.
Intervals and typical prices for the Ford Focus 4 with the 1.5 BlueHDi / EcoBlue (DV5R) engine. The app gives the exact plan for your mileage.
| Item | Interval | Typical price |
|---|---|---|
| DPF health check (soot / ash load)Emissions | every 20,000 km | €0–60 |
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| AdBlue top-upEmissions | every 15,000 km | €10–30 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Fuel filterFuel | every 30,000 km or every 24 months | €40–110 |
| Timing belt kit + water pumpEngine | every 180,000 km or every 120 months | €450–900 |
| Glow plugsEngine | every 100,000 km | €120–300 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Manual gearbox oilTransmission | every 150,000 km | €60–130 |
| Front brake padsBrakes | usually at 30,000–60,000 km | €60–150 |
| Front brake discs + padsBrakes | usually at 60,000–120,000 km | €150–320 |
| Rear brake padsBrakes | usually at 50,000–90,000 km | €50–130 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
| Version | Share | Years | CO₂ | Fuel use |
|---|---|---|---|---|
| 1.5 Diesel1,499 cm³ · 88 kW (120 hp) | 17.1 % | 2019–2025 | 122 g/km | 4.3 L |
| 1.5 Diesel1,499 cm³ · 85 kW (116 hp) | 5.5 % | 2022–2025 | 132 g/km | 5.1 L |
Source: European Environment Agency (EEA), monitoring of CO₂ emissions from new passenger cars, CC BY 4.0. CO₂ and fuel use are official type-approval values (WLTP from 2021), not real-world consumption.
Recalls the manufacturer published in the United Kingdom for this model (31). The same recalls usually apply across Europe. Ask an authorised dealer to check by VIN whether your car is affected and whether the work has been done.
The faults with the highest risk: adBlue (SCR): tank-pump unit or dosing injector fails (60,000–180,000 km, €250–1,500); brake discs groove and wear unusually early (TÜV) (60,000–240,000 km, €150–350); flat 12 V battery disables start-stop and Auto-Hold (10,000–150,000 km, €0–300).
Belt · 180,000 km / every 120 mo.
0W-30 / 5W-30 · PSA B71 2312 · ~4.25 L · every 15,000 km.
1.0 EcoBoost / 1.0 Ti-VCT (Fox)1.5 EcoBoost (3-cyl Dragon, 2018+)2.0 EcoBlue (Ford 'Panther')2.3 EcoBoost (Focus ST Mk4, Focus RS Mk3)
Peugeot 3008 II 2016–2023Citroën C3 III 2016–2024Peugeot 308 II 2013–2021Peugeot 2008 II 2019–Opel Grandland 2017–Opel Crossland 2017–Peugeot 208 II 2019–Citroën Berlingo III 2018–Peugeot Partner / Rifter (2018+) 2018–Opel Combo E 2018–Peugeot 5008 II 2017–Citroën C3 Aircross 2017–
Main sources for the faults of this engine:
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Dutch tests: RDW Open Data (CC0). Engine versions: EEA, monitoring of CO₂ emissions from new passenger cars (CC BY 4.0, DG CLIMA). Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles. How we check the data →
Updated 29/10/2026