EGR valve and cooler coking
Signs: Power loss, limp mode, EGR fault codes (e.g. P0401), black smoke
Fix: Check EGR position and flow in live data; clean or replace the valve, and the cooler if it is blocked
Diesel · 2007–2015
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
All about the Audi A4 (B8)All about the 1.2 / 1.6 / 2.0 TDI CR (EA189) engine
The 2.0 TDI CR (EA189) engine was fitted to the Audi A4 (B8) (2007–2015). In the EU that is 79.1 % of all new cars of this generation.
Versions: 2.0, 2.0 143 hp, 2.0 177 hp, 2.0 150 hp, 2.0 136 hp, 2.0 120 hp, 2.0 170 hp.
The most expensive known risk is DPF clogging or faulty DPF pressure sensor: it usually appears at 80,000–200,000 km and costs €100–1,800 to fix.
✓ The faults of this engine were checked against sources (10/2026). Each item has at least two independent sources or an official recall or parts-maker technical note.
Signs: Power loss, limp mode, EGR fault codes (e.g. P0401), black smoke
Fix: Check EGR position and flow in live data; clean or replace the valve, and the cooler if it is blocked
Signs: DPF light, frequent or interrupted regenerations, limp mode; worse with short trips
Fix: First check the differential pressure sensor and its hoses, then soot and ash load; forced regeneration, cleaning or replacement; use low-ash VW 507.00 oil
Signs: Engine light with P2015, reduced power, sometimes limp mode
Fix: Clean the manifold and fit a linkage repair kit, or replace the manifold with flaps; adapt the flaps with a diagnostic tool
Signs: Engine light, reduced power or limp mode, codes P2563 / P2564
Fix: Check vacuum lines and the control valve, the crankcase pressure valve in the cylinder head cover (1.6 TDI) and the actuator with its position sensor; clean the vanes or replace the turbo if needed
Signs: Oil pressure warning, then sudden loss of oil pressure; the engine can be destroyed
Fix: Stop the engine at once if the oil pressure light comes on; on early engines fit the revised longer (100 mm) hex shaft preventively, e.g. with the timing belt
Signs: Hard starting, power loss, rail pressure codes; metal particles can reach the injectors
Fix: Replace the pump; if there is metal debris, also injectors, rail and lines, and flush the tank; check the fuel filter for metal at services
Signs: Harder starting, rough idle, smoke, higher fuel use, high return flow on the test
Fix: Return-flow (leak-off) test and check of injector coding; recondition or replace the faulty injectors
Signs: Coolant loss, coolant traces at the timing belt cover, temperature warning
Fix: Replace the pump together with the whole timing belt kit, even if the belt is not yet due
Signs: Applies to every EA189; after the update some owners report more EGR and DPF faults
Fix: Have a dealer check by VIN that the free update was done; the 24-month extra cover after the update has expired
Signs: Clunks and creaks over bumps, vague steering, uneven tyre wear.
Fix: Replace the worn upper/lower front arms (often as a set per side), check rear subframe bushes, then align the wheels.
Signs: Kickback through the wheel on rough roads or when braking, steering fluid loss, whining pump, car tugs to one side.
Fix: Find the leak; replace the high-pressure line or recondition/replace the rack, then align the wheels.
Signs: Wet carpet (often by the pedals), water running down the trim, MMI or other modules glitching or rebooting.
Fix: Clear sunroof and cowl drains, check the cowl trim and windscreen bonding (especially after a screen replacement), dry carpets and inspect modules.
Signs: Screen freezes or restarts, slow boot, touchpad or controls not responding.
Fix: Check battery condition and for water in the car first; a software update fixes many cases, otherwise repair the unit.
Signs: One door does not lock/unlock with the fob, door-open warning stays on, boot does not open electrically.
Fix: Read the door module codes; replace the lock unit of that door or the boot release.
Signs: No warning signs.
Fix: Check the VIN for the open recall; the dealer reprograms the airbag control unit free of charge.
Signs: Slipping, high bite point
Fix: Replace clutch kit
Signs: Rattle at idle, vibration pulling away
Fix: Replace with clutch
Signs: Judder pulling away, jerks, 'gearbox fault' limp mode
Fix: Fluid every 60,000 km; repair or exchange
Signs: Gearbox warning, odd or even gears (1-3-5 or 2-4-R) drop out, delayed or wrong shifts, limp mode or no drive
Fix: Diagnose with a dealer-level tester; repair the control unit / solenoids or fit a reconditioned mechatronic unit, change the oil and filter and run the adaptations
Signs: Delayed or harsh shifts
Fix: Fluid service, repair
Typical routine maintenance cost for 100,000 km: €2,400–5,750. Sum of the services and wear parts in the plan above (about 15,000 km a year, independent workshop), without faults.
Intervals and typical prices for the Audi A4 (B8) with the 2.0 TDI CR (EA189) engine. The app gives the exact plan for your mileage.
| Item | Interval | Typical price |
|---|---|---|
| DPF health check (soot / ash load)Emissions | every 20,000 km | €0–60 |
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Fuel filterFuel | every 30,000 km or every 24 months | €40–110 |
| Glow plugsEngine | every 100,000 km | €120–300 |
| Timing belt kit + water pumpEngine | every 210,000 km or every 120 months | €450–900 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Manual gearbox oilTransmission | every 150,000 km | €60–130 |
| Front brake padsBrakes | usually at 30,000–60,000 km | €60–150 |
| Front brake discs + padsBrakes | usually at 60,000–120,000 km | €150–320 |
| Rear brake padsBrakes | usually at 50,000–90,000 km | €50–130 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
| Version | Share | Years | CO₂ | Fuel use |
|---|---|---|---|---|
| 2.0 Diesel1,968 cm³ | 28.8 % | 2010–2014 | — | — |
| 2.0 Diesel1,968 cm³ · 105 kW (143 hp) | 14.7 % | 2011–2014 | — | — |
| 2.0 Diesel1,968 cm³ · 130 kW (177 hp) | 10.3 % | 2012–2014 | — | — |
| 2.0 Diesel1,968 cm³ · 110 kW (150 hp) | 8.9 % | 2013–2014 | — | — |
| 2.0 Diesel1,968 cm³ · 100 kW (136 hp) | 7.0 % | 2011–2014 | — | — |
| 2.0 Diesel1,968 cm³ · 88 kW (120 hp) | 5.1 % | 2011–2014 | — | — |
| 2.0 Diesel1,968 cm³ · 125 kW (170 hp) | 2.3 % | 2011–2014 | — | — |
Source: European Environment Agency (EEA), monitoring of CO₂ emissions from new passenger cars, CC BY 4.0. CO₂ and fuel use are official type-approval values (WLTP from 2021), not real-world consumption.
Recalls the manufacturer published in the United Kingdom for this model (15). The same recalls usually apply across Europe. Ask an authorised dealer to check by VIN whether your car is affected and whether the work has been done.
The faults with the highest risk: DPF clogging or faulty DPF pressure sensor (80,000–200,000 km, €100–1,800); injector wear (high return flow) (150,000–250,000 km, €400–1,600); turbo boost control fault (P2563): actuator, vacuum or sooted vanes (100,000–220,000 km, €100–1,400); EGR valve and cooler coking (80,000–200,000 km, €250–1,000).
Belt · 210,000 km / every 120 mo.
5W-30 · VW 507.00 · ~4.3 L · every 15,000 km.
1.8 / 2.0 TSI / TFSI (EA888)2.7 / 3.0 TDI V63.0 TFSI V6 supercharged (Audi EA837)
Volkswagen Polo V (6R/6C) 2009–2017Volkswagen Golf VI 2008–2012Audi A3 (8P) 2003–2012Audi A1 (8X) 2010–2018Audi A6 (C7) 2011–2018Škoda Octavia II 2004–2013Volkswagen Caddy III 2004–2020Škoda Fabia II 2007–2014Škoda Yeti 2009–2017Volkswagen Transporter T5 2003–2015Volkswagen Passat B7 2010–2014SEAT Ibiza IV 2008–2017
Main sources for the faults of this engine:
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Dutch tests: RDW Open Data (CC0). Engine versions: EEA, monitoring of CO₂ emissions from new passenger cars (CC BY 4.0, DG CLIMA). Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles. How we check the data →
Updated 29/10/2026