Diesel · 2012–2018
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
All about the Toyota RAV4 (XA40)All about the 2.0d (BMW B47) engine
The 2.0d (BMW B47) engine was fitted to the Toyota RAV4 (XA40) (2012–2018). In the EU that is 16.7 % of all new cars of this generation.
The most expensive known risk is timing chain stretch at high mileage (much rarer than N47): it usually appears at 200,000–350,000 km and costs €1,500–3,500 to fix.
✓ The faults of this engine were checked against sources (10/2026). Each item has at least two independent sources or an official recall or parts-maker technical note.
Signs: Often none; coolant loss with no visible leak, white smoke, sweet smell or burning smell; in rare cases the plastic intake melts
Fix: Have a BMW or MINI dealer check by VIN whether the recall was done; the EGR cooler (and if needed the intake) is replaced free of charge
Signs: Coolant level keeps dropping without a puddle, white smoke; or power loss and EGR fault codes from a sooted valve
Fix: Pressure-test the cooling system and check EGR data; replace the EGR cooler or clean / replace the valve; check the intake for soot
Signs: DPF warning, frequent or failed regenerations, limp mode; mainly with short trips
Fix: First check the differential pressure sensor, its hoses and the thermostat; then forced regeneration, cleaning or replacement; use LL-04 oil
Signs: Rattle from the back of the engine after a cold start; cam/crank correlation faults
Fix: Have it checked at the first rattle; replace chain, guides and tensioner (gearbox side, a large job); keep oil change intervals short
Signs: Slipping, high bite point
Fix: Replace clutch kit
Signs: Rattle at idle, vibration pulling away
Fix: Replace with clutch
Signs: Delayed or harsh shifts
Fix: Fluid service, repair
Typical routine maintenance cost for 100,000 km: €2,400–5,750. Sum of the services and wear parts in the plan above (about 15,000 km a year, independent workshop), without faults.
Intervals and typical prices for the Toyota RAV4 (XA40) with the 2.0d (BMW B47) engine. The app gives the exact plan for your mileage.
| Item | Interval | Typical price |
|---|---|---|
| DPF health check (soot / ash load)Emissions | every 20,000 km | €0–60 |
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Fuel filterFuel | every 30,000 km or every 24 months | €40–110 |
| Glow plugsEngine | every 100,000 km | €120–300 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Timing chain inspection (listen on cold start)Engine | every 150,000 km | €0–120 |
| Manual gearbox oilTransmission | every 150,000 km | €60–130 |
| Front brake padsBrakes | usually at 30,000–60,000 km | €60–150 |
| Front brake discs + padsBrakes | usually at 60,000–120,000 km | €150–320 |
| Rear brake padsBrakes | usually at 50,000–90,000 km | €50–130 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
Recalls the manufacturer published in the United Kingdom for this model (6). The same recalls usually apply across Europe. Ask an authorised dealer to check by VIN whether your car is affected and whether the work has been done.
The faults with the highest risk: timing chain stretch at high mileage (much rarer than N47) (200,000–350,000 km, €1,500–3,500); DPF clogging or faulty DPF pressure sensor (120,000–250,000 km, €150–1,800); EGR cooler leak or EGR valve fault outside the recall (80,000–200,000 km, €300–1,200).
Chain.
5W-30 / 0W-30 · BMW LL-04 · ~5.2 L · every 15,000 km.
2.0 / 2.2 D-4D / D-CAT (Toyota 1AD / 2AD)2.5 Hybrid (M20A / A25A / 2AR)2.0 Dual VVT-i (Toyota NR / ZR)
BMW 3 Series (F30) 2012–2019Toyota Avensis (T27) 2009–2018BMW 1 Series (F20) 2011–2019BMW 5 Series (F10) 2010–2017BMW 5 Series (G30) 2017–2023BMW 4 Series (F32) 2013–2020BMW X1 (F48) 2015–2022BMW X3 (G01) 2017–2024BMW X3 (F25) 2010–2017BMW 1 Series (F40) 2019–2024BMW X5 (F15) 2013–2018BMW X1 (U11) 2022–
Main sources for the faults of this engine:
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Dutch tests: RDW Open Data (CC0). Engine versions: EEA, monitoring of CO₂ emissions from new passenger cars (CC BY 4.0, DG CLIMA). Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles. How we check the data →
Updated 29/10/2026