Rear axle bearings (torsion-beam axle)
usually 120,000–250,000 km · Medium risk
Signs: Rear wheels lean in, uneven tyre wear
Fix: Rebuild the rear axle
€300–800
Common faults, service intervals and costs
Renault Kangoo I
1997–2008 · Renault Kangoo 1
5
engines covered
20
known faults
15,734
roadworthiness tests in the statistics
7
official recalls
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
The Renault Kangoo I was built from 1997 to 2008.
For this generation we cover 5 engines and 20 known faults, each with the mileage range where it usually appears.
The most expensive known risk is Crankshaft (big-end) bearing failure: it usually appears at 150,000–250,000 km and costs €1,500–3,500 to fix.
In UK roadworthiness tests in 2024, at 100–150 thousand km this model most often failed on: lights, wipers and visibility (26.1 %), suspension (16.4 %), brakes (14.9 %). It fails more often than an average car of the same age and mileage on: brakes, steering, body and corrosion. It fails less often than average on: exhaust, emissions and leaks.
Engines
| Engine | Fuel | Timing drive | Oil |
|---|---|---|---|
| 1.4 / 1.6 8v MPI (Renault K7J / K7M) | Petrol | Belt · 60,000 km / every 48 mo | 10W-40 / 5W-40 · Renault RN0700 / RN0710 · ~3.3 L · every 15,000 km |
| 1.2 8v / 16v (Renault D7F / D4F) | Petrol | Belt · 90,000 km / every 60 mo | 5W-40 / 10W-40 · Renault RN0700 · ~4.0 L · every 15,000 km |
| 1.4 / 1.6 16v (Renault K4J / K4M) | Petrol | Belt · 90,000 km / every 60 mo | 5W-40 / 10W-40 · Renault RN0700 / RN0710 · ~4.8 L · every 15,000 km |
| 1.5 dCi (K9K) | Diesel | Belt · 120,000 km / every 72 mo | 5W-30 · Renault RN0720 (DPF) / RN0710 · ~4.5 L · every 10,000 km |
| 1.9 dCi / dTi (Renault F9Q) | Diesel | Belt · 120,000 km / every 60 mo | 5W-40 · Renault RN0710 · ~4.6 L · every 10,000 km |
Faults typical of this model
Rust (rear arches, sills)
usually 100,000–300,000 km · Wear part
Signs: Bubbling paint
Fix: Rust repair
€200–800
Faults by engine
1.4 / 1.6 8v MPI (Renault K7J / K7M)
Ignition coil pack / leads
usually 80,000–160,000 km · Wear part
Signs: Misfire
Fix: Replace
€60–180
Idle speed / throttle body
usually 100,000–180,000 km · Wear part
Signs: Unstable idle, stalling
Fix: Clean throttle body, replace idle motor
€60–200
Oil leaks / consumption at high mileage
usually 180,000–300,000 km · Wear part
Signs: Oil drips, topping up
Fix: Gaskets, valve stem seals
€100–600
1.2 8v / 16v (Renault D7F / D4F)
Ignition coils
usually 120,000–280,000 km · Wear part
Signs: Misfire
Fix: Replace coil
€60–180
Throttle body / idle
usually 80,000–160,000 km · Wear part
Signs: Unstable idle
Fix: Clean throttle body
€50–150
Oil consumption / head gasket (high mileage)
usually 150,000–250,000 km · Wear part
Signs: Topping up, coolant loss
Fix: Repair
€300–900
1.4 / 1.6 16v (Renault K4J / K4M)
Ignition coils
usually 120,000–280,000 km · Medium risk
Signs: Misfire, flashing engine light — very common
Fix: Replace coil (and plugs)
€60–200
Camshaft variator (VVT) rattle
usually 100,000–200,000 km · Wear part
Signs: Diesel-like rattle for a few seconds on start
Fix: Replace the variator pulley with the belt
€200–400
Oil leaks (cam cover / seals)
usually 120,000–220,000 km · Wear part
Signs: Oil drips, burning smell
Fix: Replace gaskets
€80–250
Timing belt tensioner (early failures)
usually 60,000–90,000 km · High risk
Signs: Belt failure bends valves
Fix: Replace belt kit with water pump on time
€250–500
1.5 dCi (K9K)
Injector wear
usually 150,000–250,000 km · Medium risk
Signs: Rough idle, smoke
Fix: Replace injectors
€600–1,400
Crankshaft bearing wear
usually 180,000–280,000 km · High risk
Signs: Knock under load; worse on older engines
Fix: Keep oil changes at 10,000 km
€1,500–3,000
EGR / DPF
usually 120,000–200,000 km · Medium risk
Signs: Limp mode
Fix: Clean or replace
€250–1,200
1.9 dCi / dTi (Renault F9Q)
Crankshaft (big-end) bearing failure
usually 150,000–250,000 km · High risk
Signs: Knocking, oil light — engine failure
Fix: 10,000 km oil intervals; bearing replacement
€1,500–3,500
Turbo failure (oil starvation)
usually 150,000–250,000 km · High risk
Signs: Whistle, smoke, oil loss
Fix: Replace turbo, clean the oil feed
€700–1,600
EGR valve
usually 100,000–200,000 km · Medium risk
Signs: Limp mode
Fix: Clean or replace
€200–500
Injectors (Bosch / Delphi)
usually 150,000–250,000 km · Medium risk
Signs: Knocking, smoke
Fix: Test and replace
€500–1,200
Gearboxes
Manual
Clutch wear
usually 120,000–200,000 km · Medium risk
Signs: Slipping, high bite point
Fix: Replace clutch kit
€500–900
DP0 / AL4 (4-speed automatic)
DP0 / AL4 solenoids / pressure regulator
usually 80,000–180,000 km · High risk
Signs: Gearbox warning, limp mode, harsh shifts
Fix: Solenoids / pressure sensor; fluid change
€300–1,500
Scheduled service
Intervals and typical prices for the 1.4 / 1.6 8v MPI (Renault K7J / K7M) engine. Other engines differ in oil, timing drive and some filters; the app gives the exact plan.
| Item | Interval | Typical price |
|---|---|---|
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Spark plugsIgnition | every 60,000 km or every 48 months | €50–160 |
| Timing belt kit + water pumpEngine | every 60,000 km or every 48 months | €450–900 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Manual gearbox oilTransmission | every 150,000 km | €60–130 |
| Front brake padsBrakes | usually at 30,000–60,000 km | €60–150 |
| Front brake discs + padsBrakes | usually at 60,000–120,000 km | €150–320 |
| Rear brake padsBrakes | usually at 50,000–90,000 km | €50–130 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
Roadworthiness tests by mileage
Share of tests in the United Kingdom (DVSA MOT, 2024) that this model failed because of each system. Bold red means more often and green less often than an average car of the same age and mileage. Sample: 15,734 tests.
| thousand km | 0–50 | 50–100 | 100–150 | 150–200 | 200–250 | 250+ |
|---|---|---|---|---|---|---|
| Brakes | 9.1 % | 12.3 % | 14.9 % | 17.1 % | 19.0 % | 21.0 % |
| Suspension | 5.2 % | 10.3 % | 16.4 % | 19.6 % | 22.4 % | 21.1 % |
| Steering | 5.2 % | 9.7 % | 13.5 % | 14.5 % | 16.0 % | 15.3 % |
| Tyres and wheels | 5.6 % | 7.7 % | 7.9 % | 8.7 % | 9.5 % | 10.0 % |
| Lights, wipers and visibility | 17.4 % | 20.5 % | 26.1 % | 28.7 % | 31.7 % | 30.2 % |
| Body and corrosion | 9.6 % | 10.1 % | 11.2 % | 11.2 % | 12.7 % | 11.2 % |
| Exhaust, emissions and leaks | 4.7 % | 4.9 % | 4.8 % | 5.2 % | 5.5 % | 5.4 % |
Official recalls
Recalls the manufacturer published in the United Kingdom for this model (7). The same recalls usually apply across Europe. Ask an authorised dealer to check by VIN whether your car is affected and whether the work has been done.
- Fuel system Fuel pipe protective cover may detach & damage engine28/06/2013 · R/2013/073
- Seat belt Seatbelt may fail17/01/2012 · R/2012/002
- Steering Possible loss of power assistance to the steering27/10/2009 · R/2009/116
- Doors / locks / lids Door security concern10/01/2002 · R/2001/161
- Airbag Unintentional deployment of air bags and/or seat belt pre-tensioners26/01/2001 · R/2000/137
- Airbag Unintentional deployment of air bags and/or seat belt pre-tensioners26/01/2001 · R/2000/136
- Wheels / tyres Risk of rapid loss of tyre pressure15/12/2000 · R/2000/103
Other generations
Sources and notes
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles.
Updated 07/10/2026