Rust (rear arches, sills)
usually 100,000–300,000 km · Wear part
Signs: Bubbling paint
Fix: Rust repair
€200–800
Common faults, service intervals and costs
Opel Corsa B
1993–2000
2
engines covered
12
known faults
4,196
roadworthiness tests in the statistics
9
official recalls
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
The Opel Corsa B was built from 1993 to 2000.
For this generation we cover 2 engines and 12 known faults, each with the mileage range where it usually appears.
The most expensive known risk is Solenoids / pressure regulator (limp mode): it usually appears at 100,000–200,000 km and costs €300–1,500 to fix.
In UK roadworthiness tests in 2024, at 50–100 thousand km this model most often failed on: lights, wipers and visibility (21.9 %), body and corrosion (10.8 %), suspension (10.4 %). It fails more often than an average car of the same age and mileage on: suspension, tyres and wheels, lights, wipers and visibility, body and corrosion, exhaust, emissions and leaks. It fails less often than average on: brakes.
Engines
| Engine | Fuel | Timing drive | Oil |
|---|---|---|---|
| 1.0 / 1.2 / 1.4 Twinport / Ecotec (Opel Family 0) | Petrol | Chain | 5W-30 · dexos2 · ~3.5 L · every 15,000 km |
| 1.4 / 1.6 / 1.8 / 2.0 16v Ecotec (X/Z14XE, X16XEL, Z16XE, Z18XE, 1995–2006) | Petrol | Belt · 90,000 km / every 60 mo | 10W-40 / 5W-30 · GM-LL-A-025 · ~4.25 L · every 15,000 km |
Faults typical of this model
Ignition switch / immobiliser
usually 120,000–250,000 km · Wear part
Signs: Won't start intermittently
Fix: Replace switch / ring antenna
€100–300
Faults by engine
1.0 / 1.2 / 1.4 Twinport / Ecotec (Opel Family 0)
Timing chain stretch
usually 60,000–150,000 km · High risk
Signs: Rattle on cold start, timing codes — the chain can jump
Fix: Replace chain, tensioner and guides
€400–800
Twinport intake flap actuator
usually 80,000–160,000 km · Medium risk
engine codes: Z10XEP, Z12XEP, Z14XEP, A10XEP, A12XEL
Signs: Engine light, flat spot
Fix: Replace actuator / manifold
€150–450
EGR valve sticking
usually 80,000–160,000 km · Medium risk
engine codes: Z10XEP, Z12XEP, Z14XEP, Z10XE, Z12XE
Signs: Unstable idle, stalling
Fix: Clean or replace EGR
€100–300
Thermostat housing / coolant leaks
usually 80,000–160,000 km · Wear part
Signs: Coolant loss
Fix: Replace housing
€100–300
1.4 / 1.6 / 1.8 / 2.0 16v Ecotec (X/Z14XE, X16XEL, Z16XE, Z18XE, 1995–2006)
Timing belt tensioner / idler (early failures)
usually 60,000–90,000 km · High risk
Signs: Belt failure bends valves — change on time
Fix: Replace the full belt kit
€250–500
EGR valve (Z16XE / Z18XE)
usually 80,000–160,000 km · Medium risk
Signs: Unstable idle, stalling
Fix: Clean or replace EGR
€100–300
Ignition module / leads
usually 80,000–160,000 km · Wear part
Signs: Misfire
Fix: Replace module
€100–300
Oil leaks (cam cover, oil cooler)
usually 120,000–220,000 km · Wear part
Signs: Oil drips
Fix: Replace gaskets
€80–250
Gearboxes
Manual
Clutch wear
usually 120,000–200,000 km · Medium risk
Signs: Slipping, high bite point
Fix: Replace clutch kit
€500–900
Automatic 4-speed (AF13 / AF17 / 4T40)
Solenoids / pressure regulator (limp mode)
usually 100,000–200,000 km · High risk
Signs: Harsh shifts, stuck in 3rd, gearbox warning
Fix: Fluid change, solenoid / valve body repair
€300–1,500
Scheduled service
Intervals and typical prices for the 1.0 / 1.2 / 1.4 Twinport / Ecotec (Opel Family 0) engine. Other engines differ in oil, timing drive and some filters; the app gives the exact plan.
| Item | Interval | Typical price |
|---|---|---|
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Spark plugsIgnition | every 60,000 km or every 48 months | €50–160 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Timing chain inspection (listen on cold start)Engine | every 150,000 km | €0–120 |
| Manual gearbox oilTransmission | every 150,000 km | €60–130 |
| Front brake padsBrakes | usually at 30,000–60,000 km | €60–150 |
| Front brake discs + padsBrakes | usually at 60,000–120,000 km | €150–320 |
| Rear brake padsBrakes | usually at 50,000–90,000 km | €50–130 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
Roadworthiness tests by mileage
Share of tests in the United Kingdom (DVSA MOT, 2024) that this model failed because of each system. Bold red means more often and green less often than an average car of the same age and mileage. Sample: 4,196 tests.
| thousand km | 50–100 | 100–150 | 150–200 |
|---|---|---|---|
| Brakes | 6.6 % | 9.8 % | 11.0 % |
| Suspension | 10.4 % | 16.9 % | 19.0 % |
| Steering | 2.2 % | 4.3 % | 4.6 % |
| Tyres and wheels | 4.7 % | 5.9 % | 5.5 % |
| Lights, wipers and visibility | 21.9 % | 26.0 % | 27.8 % |
| Body and corrosion | 10.8 % | 12.3 % | 14.3 % |
| Exhaust, emissions and leaks | 7.5 % | 9.1 % | 10.8 % |
Roadworthiness tests in the Netherlands by age
Share of this model's Dutch fleet that had a defect in each system at a roadworthiness test (APK) in 2025. Bold red means more often and green less often than an average car of the same age and fuel. Sample: 2,809 cars.
| age (years) | 20+ |
|---|---|
| Brakes | 5.9 % |
| Suspension | 5.4 % |
| Steering | 2.9 % |
| Tyres and wheels | 15.4 % |
| Lights, wipers and visibility | 25.9 % |
| Body and corrosion | 1.7 % |
| Exhaust, emissions and leaks | 9.7 % |
Official recalls
Recalls the manufacturer published in the United Kingdom for this model (9). The same recalls usually apply across Europe. Ask an authorised dealer to check by VIN whether your car is affected and whether the work has been done.
- Brakes / ABS / ESP Braking performance may be reduced10/06/2008 · R/2008/068
- Steering Steering may fail20/12/2007 · R/2007/166
- Steering Steering control may be lost07/02/2007 · R/2007/024
- Fire risk Water ingress into ABS wiring may cause a short circuit and a fire22/03/2006 · R/2006/006
- Steering Steering wheel centre screw may not have been tightened correctly.11/03/2004 · R/2004/019
- Seat belt Seat belt latching concern09/02/2001 · R/2001/004
- Seats Seat security concern09/02/2001 · R/2001/005
- Fire risk Possible fire risk22/05/1998 · R/1997/098
The other recalls (1) are listed in the app.
Common questions
Does the Opel Corsa B have a timing chain or a timing belt?
1.0 / 1.2 / 1.4 Twinport / Ecotec (Opel Family 0): chain; 1.4 / 1.6 / 1.8 / 2.0 16v Ecotec (X/Z14XE, X16XEL, Z16XE, Z18XE, 1995–2006): belt · 90,000 km / every 60 mo.
What are the known problems with the Opel Corsa B?
The faults with the highest risk: solenoids / pressure regulator (limp mode) (100,000–200,000 km, €300–1,500); timing chain stretch (60,000–150,000 km, €400–800); timing belt tensioner / idler (early failures) (60,000–90,000 km, €250–500); clutch wear (120,000–200,000 km, €500–900). The full list by engine is on this page.
What does the Opel Corsa B most often fail its roadworthiness test on?
In UK roadworthiness tests in 2024, at 50–100 thousand km this model most often failed on: lights, wipers and visibility (21.9 %), body and corrosion (10.8 %), suspension (10.4 %). It fails more often than an average car of the same age and mileage on: suspension, tyres and wheels, lights, wipers and visibility, body and corrosion, exhaust, emissions and leaks. It fails less often than average on: brakes.
What should you check when buying a used Opel Corsa B?
Before you buy, ask an authorised dealer to check by VIN that the recalls have been done (9 have been published for this model). If the engine has a timing belt, ask for the invoice for its replacement: with no proof, assume it has not been done. On the test drive, watch for these signs: harsh shifts, stuck in 3rd, gearbox warning; rattle on cold start, timing codes — the chain can jump. The full checklist is in the guide to buying a used car.
Models with the same engines
These models share engines with this car, so they share some of its faults too.
Opel Astra G 1998–2004Opel Corsa C 2000–2006Opel Zafira A 1999–2005Opel Vectra B 1995–2002Opel Astra F 1991–1998Opel Agila A 2000–2007Opel Tigra 1994–2009Opel Omega B 1994–2003
Other Opel models
Sources and notes
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Dutch tests: RDW Open Data (CC0). Engine versions: EEA, monitoring of CO₂ emissions from new passenger cars (CC BY 4.0, DG CLIMA). Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles.
Updated 08/10/2026