Hybrid · 2016–now
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
All about the Toyota C-HRAll about the 1.8 Hybrid (2ZR-FXE) engine
The 1.8 Hybrid (2ZR-FXE) engine was fitted to the Toyota C-HR (2016–now). In the EU that is 72.0 % of all new cars of this generation.
Versions: 1.8 98 hp, 1.8.
The most expensive known risk is hybrid battery ageing (weak modules): it usually appears at 200,000–350,000 km and costs €1,500–3,500 to fix.
✓ The faults of this engine were checked against sources (10/2026). Each item has at least two independent sources or an official recall or parts-maker technical note.
Signs: Coolant level drops, check engine light with P148F, weak cabin heating, sometimes vapour from the exhaust
Fix: Pressure-test the cooling system; replace the front exhaust pipe with the heat exchanger (and catalyst); ask the dealer about emissions warranty cover
Signs: Check engine light with P0A80 or P0A7F, fan noise from the rear seat area, battery runs hot and wears faster
Fix: Remove and clean the battery fan and air duct, clean or replace the intake filter; check the battery itself if the codes return
Signs: Check Hybrid System warning with P0A80, engine runs more often, fuel use up, charge display swings between full and empty
Fix: Have the battery tested (Toyota Hybrid Health Check); replace the pack with a new or quality reconditioned one, and clean its cooling fan at the same time
Signs: Car will not go to READY or start after a few days parked; random warning lights from low voltage.
Fix: Test and charge the 12 V battery, ask the dealer for software updates against quiescent drain and fit a larger battery if it keeps going flat; use a maintenance charger if the car is used rarely.
Signs: A crack appears near the top (often top right) of the windscreen without an obvious stone hit and grows downward.
Fix: Replace the windscreen and have the front camera recalibrated; claim it on glass insurance.
Signs: Usually none; in the worst case warning lights, loss of power or smoke from the engine bay.
Fix: Check the VIN for the 2018 harness recall; the dealer repairs and protects the harness free of charge.
Signs: Noise or play at a rear wheel; in the worst case damage to the rear brake or a loose wheel.
Fix: Check the VIN for the open recall; the dealer checks the hub bolts and replaces the hub bearing if needed, free of charge.
Signs: Possible play or noise at the brake pedal; in the worst case reduced braking.
Fix: Check the VIN for the open recall; the dealer retightens or replaces the bolt free of charge.
Signs: Pre-collision system warning or automatic emergency braking and radar cruise not working.
Fix: Check the VIN for the open recall; the dealer initialises the radar sensor free of charge.
Signs: SOS / eCall warning in the cluster; emergency call may not connect.
Fix: Check the VIN for the open campaign; the dealer updates the DCM software free of charge.
Signs: Slipping, high bite point
Fix: Replace clutch kit
Typical routine maintenance cost for 100,000 km: €1,950–4,500. Sum of the services and wear parts in the plan above (about 15,000 km a year, independent workshop), without faults.
Intervals and typical prices for the Toyota C-HR with the 1.8 Hybrid (2ZR-FXE) engine. The app gives the exact plan for your mileage.
| Item | Interval | Typical price |
|---|---|---|
| Inverter coolantHybrid system | every 160,000 km or every 120 months | €80–160 |
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Spark plugsIgnition | every 60,000 km or every 48 months | €50–160 |
| Hybrid battery cooling filter cleanHybrid system | every 30,000 km | €0–40 |
| Hybrid transaxle fluidTransmission | every 100,000 km | €80–160 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Timing chain inspection (listen on cold start)Engine | every 150,000 km | €0–120 |
| Brake pads (regen-assisted)Brakes | usually at 80,000–160,000 km | €60–150 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
| Version | Share | Years | CO₂ | Fuel use |
|---|---|---|---|---|
| 1.8 Hybrid1,798 cm³ · 72 kW (98 hp) | 47.1 % | 2017–2025 | 109 g/km | 4.9 L |
| 1.8 Petrol1,798 cm³ · 72 kW (98 hp) | 22.3 % | 2016–2025 | 104 g/km | 4.8 L |
| 1.8 Petrol1,798 cm³ | 1.4 % | 2016–2025 | 86 g/km | 5.8 L |
Source: European Environment Agency (EEA), monitoring of CO₂ emissions from new passenger cars, CC BY 4.0. CO₂ and fuel use are official type-approval values (WLTP from 2021), not real-world consumption.
Recalls the manufacturer published in the United Kingdom for this model (12). The same recalls usually apply across Europe. Ask an authorised dealer to check by VIN whether your car is affected and whether the work has been done.
The faults with the highest risk: hybrid battery ageing (weak modules) (200,000–350,000 km, €1,500–3,500); hybrid battery cooling fan or intake filter clogged with dust (60,000–250,000 km, €50–250).
Chain.
0W-20 · API SN / ILSAC GF-5 · ~4.2 L · every 15,000 km.
2.0 Hybrid (M20A / A25A / 2AR)1.0 / 1.2T / 1.33 / 1.5 petrol (Toyota KR / NR / M15A)
Toyota Corolla (E210) 2019–Toyota Prius IV 2015–2022Toyota Prius III 2009–2015Lexus CT 200h 2011–2022
Main sources for the faults of this engine:
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Dutch tests: RDW Open Data (CC0). Engine versions: EEA, monitoring of CO₂ emissions from new passenger cars (CC BY 4.0, DG CLIMA). Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles. How we check the data →
Updated 29/10/2026