EGR valve and cooler coking
usually 80,000–160,000 km · Medium risk
Signs: Power loss, limp mode, EGR fault codes (P0401, P0403, P2413)
Fix: Check actual EGR flow in live data, clean or replace the valve; the cooler if it is blocked
€150–900
Faults and service for this model with this engine
Škoda Rapid 1.4 / 1.6 TDI (EA288)
Diesel · 2012–2019
12
known faults
3
Faults typical of this model
16.0 %
Share
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
All about the Škoda RapidAll about the 1.4 / 1.6 / 2.0 TDI (EA288) engine
The 1.4 / 1.6 TDI (EA288) engine was fitted to the Škoda Rapid (2012–2019). In the EU that is 16.0 % of all new cars of this generation.
Versions: 1.6 105 hp, 1.4 90 hp, 1.6 116 hp, 1.6 90 hp.
The most expensive known risk is high-pressure fuel pump (Bosch CP4): it usually appears at 150,000–300,000 km and costs €1,200–4,000 to fix.
Engine faults ✓ Checked against sources (10/2026)
✓ The faults of this engine were checked against sources (10/2026). Each item has at least two independent sources or an official recall or parts-maker technical note.
EGR cooler internal leak
usually 100,000–180,000 km · High risk
Signs: Coolant loss with no visible leak, white smoke after a cold start
Fix: Pressure-test the cooling system and replace the EGR cooler before the cylinder head is damaged
€450–1,300
Intercooler in the intake manifold cracks (coolant leak)
usually 100,000–200,000 km · High risk
Signs: Coolant loss with no visible leak, oily emulsion on the block at cylinder 4 near the bulkhead
Fix: Pressurise the cooling system and inspect the cooler with an endoscope through the charge-air temperature sensor opening; replace the intake manifold with cooler
€600–1,400
Switchable coolant pump: shroud sticks or leaks
usually 80,000–150,000 km · High risk
Signs: Overheating (shroud stuck closed) or slow warm-up and weak heating (stuck open), coolant loss, pink crust near the pump
Fix: Replace the pump, ideally together with the timing belt
€300–1,200
Coolant expansion tank: silicate bag breaks up
usually 60,000–200,000 km · Wear part
Signs: Granules in the coolant, poor cabin heating (clogged heater core)
Fix: Replace the expansion tank and flush the cooling system and heater core
€100–400
DPF clogging
usually 60,000–180,000 km · Medium risk
Signs: DPF light, regeneration every few days, rising oil level (fuel in the oil)
Fix: Longer motorway drives; check soot and ash load and the pressure sensor; forced regeneration, cleaning or replacement
€150–1,800
Oil pump drive belt (in the sump)
usually 150,000–250,000 km · Medium risk
Signs: Oil pressure warning, noise from the lower part of the engine
Fix: Stop the engine at once if the oil pressure light comes on; at high mileage replace the oil pump belt preventively
€300–600
Timing belt tensioner: revised part (engines built before 10/2016)
usually 60,000–210,000 km · Medium risk
model years 2012–2016 only
Signs: Squeal from the timing belt area; a slack belt after a belt change
Fix: Fit the revised tensioner; at a belt change loosen the camshaft and pump sprockets so the tension is even (INA instruction)
€100–300
Injector wear (return flow)
usually 150,000–250,000 km · Medium risk
Signs: Harder starting, louder clatter when cold, rough idle, high return flow on the test
Fix: Return-flow (leak-off) test; recondition or replace the injectors
€400–1,500
High-pressure fuel pump (Bosch CP4)
usually 150,000–300,000 km · Medium risk
Signs: Hard starting, power loss, rail pressure codes; metal particles can reach the injectors
Fix: Replace the pump; if there is metal debris, also injectors, rail and lines, and flush the tank
€1,200–4,000
Turbocharger: sooted vanes, actuator or bearing play
usually 150,000–250,000 km · Medium risk
Signs: Limp mode, boost pressure codes, whistling, oil in the intake
Fix: Clean the variable vanes or repair the actuator; replace or recondition the turbo
€900–2,000
Oil leak from the camshaft housing
usually 120,000–220,000 km · Wear part
Signs: Oil on top of the cylinder head, oil reaching the timing belt
Fix: Reseal the camshaft housing, usually together with the timing belt change
€300–800
Faults typical of this model
Door lock / central locking
usually 80,000–200,000 km · Wear part
Signs: Doors don't lock
Fix: Replace the lock unit
€80–220
Front anti-roll bar links / bushes
usually 120,000–280,000 km · Wear part
Signs: Knocking over bumps
Fix: Replace links / bushes
€60–150
Heater blower resistor
usually 80,000–200,000 km · Wear part
Signs: Fan works only on some speeds
Fix: Replace resistor
€30–90
Gearboxes
Manual
Clutch wear
usually 120,000–200,000 km · Medium risk
Signs: Slipping, high bite point
Fix: Replace clutch kit
€500–900
DSG DQ200 (7-speed, dry clutch)
Mechatronic pressure loss (cracked accumulator / valve-body housing)
usually 60,000–200,000 km · High risk
Signs: Jerky or hard shifts, flashing gear display, odd or even gears drop out, then limp mode or the car will not move (codes such as P17BF)
Fix: Have the hydraulic pressure checked by a DSG specialist; repair the housing / accumulator with a revised kit or fit a reconditioned mechatronic unit, then run the adaptations
€700–2,500
Early dry-clutch wear: judder and slip when pulling away
usually 50,000–150,000 km · Medium risk
Signs: Judder or shudder when pulling away or parking, slipping, burning smell, warning to stop when the clutch is hot
Fix: Read clutch wear and adaptation values with a dealer-level tester; reset adaptations first, replace the double clutch (with release levers / bearings) if worn
€900–1,600
Service plan for this engine
Typical routine maintenance cost for 100,000 km: €2,400–5,750. Sum of the services and wear parts in the plan above (about 15,000 km a year, independent workshop), without faults.
Intervals and typical prices for the Škoda Rapid with the 1.4 / 1.6 TDI (EA288) engine. The app gives the exact plan for your mileage.
| Item | Interval | Typical price |
|---|---|---|
| DPF health check (soot / ash load)Emissions | every 20,000 km | €0–60 |
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Fuel filterFuel | every 30,000 km or every 24 months | €40–110 |
| Glow plugsEngine | every 100,000 km | €120–300 |
| Timing belt kit + water pumpEngine | every 210,000 km or every 120 months | €450–900 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Manual gearbox oilTransmission | every 150,000 km | €60–130 |
| Front brake padsBrakes | usually at 30,000–60,000 km | €60–150 |
| Front brake discs + padsBrakes | usually at 60,000–120,000 km | €150–320 |
| Rear brake padsBrakes | usually at 50,000–90,000 km | €50–130 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
Versions of this engine in the Škoda Rapid
| Version | Share | Years | CO₂ | Fuel use |
|---|---|---|---|---|
| 1.6 Diesel1,598 cm³ · 77 kW (105 hp) | 5.8 % | 2012–2016 | — | — |
| 1.4 Diesel1,422 cm³ · 66 kW (90 hp) | 5.3 % | 2015–2019 | 103 g/km | — |
| 1.6 Diesel1,598 cm³ · 85 kW (116 hp) | 4.9 % | 2015–2019 | 107 g/km | — |
| 1.6 Diesel1,598 cm³ · 66 kW (90 hp) | 4.7 % | 2013–2019 | 105 g/km | — |
Source: European Environment Agency (EEA), monitoring of CO₂ emissions from new passenger cars, CC BY 4.0. CO₂ and fuel use are official type-approval values (WLTP from 2021), not real-world consumption.
Official recalls
Recalls the manufacturer published in the United Kingdom for this model (6). The same recalls usually apply across Europe. Ask an authorised dealer to check by VIN whether your car is affected and whether the work has been done.
- Airbag Replacing TAKATA driver airbag02/09/2026 · R/2026/342
- Airbag Takata drivers side front airbag18/07/2025 · R/2026/002
- Airbag On affected vehicles from a certain production period there is a possibility that the gas generator cover could be damaged when the driver's airbag is activated.27/03/2023 · R/2023/086
- Airbag Air bag may not inflate quickly enough on deployment30/05/2019 · R/2019/210
- Seat belt Parts of seat belt pretensioner may be dislodged on deployment22/06/2017 · R/2017/192
- Doors / locks / lids Manual child locks on rear passenger doors may disengage without warning07/07/2016 · R/2016/158
Common questions
What are the biggest risks of the Škoda Rapid with the 1.4 / 1.6 TDI (EA288) engine?
The faults with the highest risk: intercooler in the intake manifold cracks (coolant leak) (100,000–200,000 km, €600–1,400); EGR cooler internal leak (100,000–180,000 km, €450–1,300); switchable coolant pump: shroud sticks or leaks (80,000–150,000 km, €300–1,200); high-pressure fuel pump (Bosch CP4) (150,000–300,000 km, €1,200–4,000).
Does the Škoda Rapid 1.4 / 1.6 TDI (EA288) have a timing belt or a chain?
Belt · 210,000 km / every 120 mo.
Which oil does the Škoda Rapid 1.4 / 1.6 TDI (EA288) need?
0W-30 / 5W-30 · VW 507.00 · ~4.3–4.6 L · every 15,000 km.
The same model with other engines
1.0 / 1.2 TSI (EA211)1.2 / 1.4 TSI / TFSI (EA111)1.0 / 1.6 MPI (EA211: CHYA / CWVA)1.2 / 1.6 / 2.0 TDI CR (EA189)1.2 HTP 3-cyl (6v / 12v)
Other models with the 1.4 / 1.6 / 2.0 TDI (EA288) engine
Volkswagen Golf VII 2012–2020Škoda Octavia III 2013–2020Audi A3 (8V) 2012–2020Volkswagen Polo V (6R/6C) 2009–2017Volkswagen Passat B8 2014–2023Audi A4 (B9) 2015–2024Škoda Superb III 2015–2023Škoda Octavia IV 2020–Audi A1 (8X) 2010–2018Volkswagen Tiguan II 2016–2024Audi A6 (C7) 2011–2018SEAT León III 2012–2020
Sources and notes
Main sources for the faults of this engine:
- Schaeffler REPXPERT
- INA
- ContiTech
- motorenlager.de
- kfz-dietrich.com
- carwiki.de
- autocentrum.pl
- enginedna.com
- autoscore.pro
- torquecars.com
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Dutch tests: RDW Open Data (CC0). Engine versions: EEA, monitoring of CO₂ emissions from new passenger cars (CC BY 4.0, DG CLIMA). Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles. How we check the data →
Updated 29/10/2026