EGR valve and cooler coking
usually 80,000–160,000 km · Medium risk
Signs: Power loss, limp mode, EGR fault codes (P0401, P0403, P2413)
Fix: Check actual EGR flow in live data, clean or replace the valve; the cooler if it is blocked
€150–900
Faults and service for this model with this engine
Škoda Karoq 1.6 / 2.0 TDI (EA288)
Diesel · 2017–now
11
known faults
7
Faults typical of this model
33.9 %
Share
Enter your VIN and mileage and get a plan built for your exact engine and gearbox.
All about the Škoda KaroqAll about the 1.4 / 1.6 / 2.0 TDI (EA288) engine
The 1.6 / 2.0 TDI (EA288) engine was fitted to the Škoda Karoq (2017–now). In the EU that is 33.9 % of all new cars of this generation.
Versions: 2.0 150 hp, 1.6 116 hp, 2.0 116 hp.
The most expensive known risk is high-pressure fuel pump (Bosch CP4): it usually appears at 150,000–300,000 km and costs €1,200–4,000 to fix.
Engine faults ✓ Checked against sources (10/2026)
✓ The faults of this engine were checked against sources (10/2026). Each item has at least two independent sources or an official recall or parts-maker technical note.
EGR cooler internal leak
usually 100,000–180,000 km · High risk
Signs: Coolant loss with no visible leak, white smoke after a cold start
Fix: Pressure-test the cooling system and replace the EGR cooler before the cylinder head is damaged
€450–1,300
Intercooler in the intake manifold cracks (coolant leak)
usually 100,000–200,000 km · High risk
Signs: Coolant loss with no visible leak, oily emulsion on the block at cylinder 4 near the bulkhead
Fix: Pressurise the cooling system and inspect the cooler with an endoscope through the charge-air temperature sensor opening; replace the intake manifold with cooler
€600–1,400
Switchable coolant pump: shroud sticks or leaks
usually 80,000–150,000 km · High risk
Signs: Overheating (shroud stuck closed) or slow warm-up and weak heating (stuck open), coolant loss, pink crust near the pump
Fix: Replace the pump, ideally together with the timing belt
€300–1,200
Coolant expansion tank: silicate bag breaks up
usually 60,000–200,000 km · Wear part
Signs: Granules in the coolant, poor cabin heating (clogged heater core)
Fix: Replace the expansion tank and flush the cooling system and heater core
€100–400
DPF clogging
usually 60,000–180,000 km · Medium risk
Signs: DPF light, regeneration every few days, rising oil level (fuel in the oil)
Fix: Longer motorway drives; check soot and ash load and the pressure sensor; forced regeneration, cleaning or replacement
€150–1,800
Oil pump drive belt (in the sump)
usually 150,000–250,000 km · Medium risk
Signs: Oil pressure warning, noise from the lower part of the engine
Fix: Stop the engine at once if the oil pressure light comes on; at high mileage replace the oil pump belt preventively
€300–600
Injector wear (return flow)
usually 150,000–250,000 km · Medium risk
Signs: Harder starting, louder clatter when cold, rough idle, high return flow on the test
Fix: Return-flow (leak-off) test; recondition or replace the injectors
€400–1,500
High-pressure fuel pump (Bosch CP4)
usually 150,000–300,000 km · Medium risk
Signs: Hard starting, power loss, rail pressure codes; metal particles can reach the injectors
Fix: Replace the pump; if there is metal debris, also injectors, rail and lines, and flush the tank
€1,200–4,000
Turbocharger: sooted vanes, actuator or bearing play
usually 150,000–250,000 km · Medium risk
Signs: Limp mode, boost pressure codes, whistling, oil in the intake
Fix: Clean the variable vanes or repair the actuator; replace or recondition the turbo
€900–2,000
Oil leak from the camshaft housing
usually 120,000–220,000 km · Wear part
Signs: Oil on top of the cylinder head, oil reaching the timing belt
Fix: Reseal the camshaft housing, usually together with the timing belt change
€300–800
Faults typical of this model ✓ Checked against sources (10/2026)
Recall: steering gear mounting bolt can corrode and break
at any mileage · High risk
model years 2017–2026 only
Signs: Usually no warning; in the worst case knocking from the steering and then loss of steering after years of road-salt exposure.
Fix: Check the VIN for campaign 48LS; the dealer replaces the bolt with a corrosion-resistant one free of charge.
free / recall
Recall: electric parking brake can release by itself (1.0 TSI manual)
usually 0–200,000 km · High risk
model years 2017–2018 onlyengine codes: DKRF
Signs: No warning; a misread neutral signal can make the car think a gear is engaged and release the parking brake, so a parked car may roll away.
Fix: Check the VIN for the November 2018 recall; the dealer updates the ESC module software free of charge.
free / recall
Recall: brake pedal plate weld can fail (2020-2021)
usually 0–200,000 km · High risk
model years 2020–2021 only
Signs: No warning; under hard braking the pedal plate can bend or in the worst case come off.
Fix: Check the VIN for the open recall; the dealer checks the weld and replaces the brake pedal if needed, free of charge.
free / recall
Recall: A-pillar trim can break off when the head airbag fires (2018)
usually 0–200,000 km · Medium risk
model years 2017–2018 only
Signs: No warning; in frost the fleece inside the A-pillar trim can come unstuck, so trim pieces may fly into the cabin when the curtain airbag deploys.
Fix: Check the VIN for the January 2018 recall; the dealer replaces both A-pillar trims free of charge.
free / recall
Recalls: rear headrest mount and driver seat frame welds (2018-2019)
usually 0–200,000 km · Medium risk
model years 2018–2019 only
Signs: No warning; a weak weld can make a rear headrest or the driver's seat frame give way in a crash.
Fix: Check the VIN for open seat recalls; the dealer checks the welds and replaces the backrest or seat frame if needed, free of charge.
free / recall
Axle springs, mounts and dampers flagged at 4-5 years
usually 60,000–150,000 km · Wear part
Signs: Knocks or creaks from the suspension over bumps, inspection note on springs or axle mounts.
Fix: Inspect springs, bushes and dampers on a lift and replace the worn parts; springs and dampers in axle pairs.
€150–600
Infotainment and driver-assist software faults
usually 0–150,000 km · Wear part
Signs: Bluetooth / CarPlay drops, radio or navigation restarts, ACC, traffic-sign recognition or Travel Assist unavailable.
Fix: Read the module codes, check the 12 V battery and install current software; clean the windscreen camera and radar area before replacing any sensor.
€0–300
Gearboxes
Manual
Clutch wear
usually 120,000–200,000 km · Medium risk
Signs: Slipping, high bite point
Fix: Replace clutch kit
€500–900
DSG DQ200 (7-speed, dry clutch)
Mechatronic pressure loss (cracked accumulator / valve-body housing)
usually 60,000–200,000 km · High risk
Signs: Jerky or hard shifts, flashing gear display, odd or even gears drop out, then limp mode or the car will not move (codes such as P17BF)
Fix: Have the hydraulic pressure checked by a DSG specialist; repair the housing / accumulator with a revised kit or fit a reconditioned mechatronic unit, then run the adaptations
€700–2,500
Early dry-clutch wear: judder and slip when pulling away
usually 50,000–150,000 km · Medium risk
Signs: Judder or shudder when pulling away or parking, slipping, burning smell, warning to stop when the clutch is hot
Fix: Read clutch wear and adaptation values with a dealer-level tester; reset adaptations first, replace the double clutch (with release levers / bearings) if worn
€900–1,600
DSG / S tronic (wet clutch: DQ250 / DQ381 / DL501)
Wet DSG mechatronic / control unit failure
usually 80,000–220,000 km · High risk
Signs: Gearbox warning, odd or even gears (1-3-5 or 2-4-R) drop out, delayed or wrong shifts, limp mode or no drive
Fix: Diagnose with a dealer-level tester; repair the control unit / solenoids or fit a reconditioned mechatronic unit, change the oil and filter and run the adaptations
€800–2,500
DQ381 jerky low-speed downshifts and delayed take-off
usually 20,000–240,000 km · Wear part
model years 2016–2027 only
Signs: Knock or jerk when shifting down into 3rd or 2nd in traffic, a pause of 1-3 seconds before the car pulls away
Fix: Ask the dealer for the latest gearbox software, change the oil and filter and reset the adaptations; if it persists, have the mechatronic checked
€0–400
Service plan for this engine
Typical routine maintenance cost for 100,000 km: €2,400–5,750. Sum of the services and wear parts in the plan above (about 15,000 km a year, independent workshop), without faults.
Intervals and typical prices for the Škoda Karoq with the 1.6 / 2.0 TDI (EA288) engine. The app gives the exact plan for your mileage.
| Item | Interval | Typical price |
|---|---|---|
| DPF health check (soot / ash load)Emissions | every 20,000 km | €0–60 |
| Engine oil + oil filterEngine | every 15,000 km or every 12 months | €70–150 |
| Cabin (pollen) filterClimate | every 15,000 km or every 12 months | €15–40 |
| Brake fluidBrakes | every 24 months | €50–95 |
| A/C service (regas + desiccant)Climate | every 24 months | €70–150 |
| Air filterEngine | every 30,000 km or every 24 months | €15–45 |
| Fuel filterFuel | every 30,000 km or every 24 months | €40–110 |
| Glow plugsEngine | every 100,000 km | €120–300 |
| Timing belt kit + water pumpEngine | every 210,000 km or every 120 months | €450–900 |
| Auxiliary (serpentine) beltEngine | every 120,000 km | €70–180 |
| Coolant replacementCooling | every 150,000 km or every 96 months | €70–150 |
| Manual gearbox oilTransmission | every 150,000 km | €60–130 |
| Front brake padsBrakes | usually at 30,000–60,000 km | €60–150 |
| Front brake discs + padsBrakes | usually at 60,000–120,000 km | €150–320 |
| Rear brake padsBrakes | usually at 50,000–90,000 km | €50–130 |
| Tyres (set of 4)Wheels | usually at 40,000–60,000 km | €320–700 |
| Wiper bladesBody | checked at service | €20–50 |
| 12V batteryElectrical | checked at service | €100–220 |
Versions of this engine in the Škoda Karoq
| Version | Share | Years | CO₂ | Fuel use |
|---|---|---|---|---|
| 2.0 Diesel1,968 cm³ · 110 kW (150 hp) | 18.2 % | 2017–2025 | 153 g/km | 5.5 L |
| 1.6 Diesel1,598 cm³ · 85 kW (116 hp) | 7.2 % | 2017–2021 | 152 g/km | 4.7 L |
| 2.0 Diesel1,968 cm³ · 85 kW (116 hp) | 7.0 % | 2020–2025 | 129 g/km | 4.8 L |
Source: European Environment Agency (EEA), monitoring of CO₂ emissions from new passenger cars, CC BY 4.0. CO₂ and fuel use are official type-approval values (WLTP from 2021), not real-world consumption.
Official recalls
Recalls the manufacturer published in the United Kingdom for this model (6). The same recalls usually apply across Europe. Ask an authorised dealer to check by VIN whether your car is affected and whether the work has been done.
- Engine / loss of power Too little torque may be provided by the engine at low engine speeds05/09/2019 · R/2019/303
- Steering Possible crack on the frame of the left front seat09/07/2019 · R/2019/214
- Airbag Possible discrepancy in the manufacturing process of the centre rear seat head restraint06/03/2019 · R/2019/079
- Airbag A welded connection of the rear seat bench may not have been correctly performed14/12/2018 · R/2018/357
- Brakes / ABS / ESP The electro-mechanical parking brake may be released inappropriately when disengaging the clutch pedal23/11/2018 · R/2018/329
- Airbag A-pillar passenger protection trims may peel off in sub-zero temperatures15/01/2018 · R/2018/016
Common questions
What are the biggest risks of the Škoda Karoq with the 1.6 / 2.0 TDI (EA288) engine?
The faults with the highest risk: intercooler in the intake manifold cracks (coolant leak) (100,000–200,000 km, €600–1,400); EGR cooler internal leak (100,000–180,000 km, €450–1,300); switchable coolant pump: shroud sticks or leaks (80,000–150,000 km, €300–1,200); high-pressure fuel pump (Bosch CP4) (150,000–300,000 km, €1,200–4,000).
Does the Škoda Karoq 1.6 / 2.0 TDI (EA288) have a timing belt or a chain?
Belt · 210,000 km / every 120 mo.
Which oil does the Škoda Karoq 1.6 / 2.0 TDI (EA288) need?
0W-30 / 5W-30 · VW 507.00 · ~4.3–4.6 L · every 15,000 km.
The same model with other engines
Other models with the 1.4 / 1.6 / 2.0 TDI (EA288) engine
Volkswagen Golf VII 2012–2020Škoda Octavia III 2013–2020Audi A3 (8V) 2012–2020Volkswagen Polo V (6R/6C) 2009–2017Volkswagen Passat B8 2014–2023Audi A4 (B9) 2015–2024Škoda Superb III 2015–2023Škoda Octavia IV 2020–Audi A1 (8X) 2010–2018Volkswagen Tiguan II 2016–2024Audi A6 (C7) 2011–2018SEAT León III 2012–2020
Sources and notes
Main sources for the faults of this engine:
- Schaeffler REPXPERT
- INA
- ContiTech
- motorenlager.de
- kfz-dietrich.com
- carwiki.de
- autocentrum.pl
- enginedna.com
- autoscore.pro
- torquecars.com
Faults, intervals and prices are indicative and collected from public sources and owner experience; always rely on the service book and a qualified workshop. Test statistics: DVSA – Anonymised MOT tests and results, Open Government Licence v3.0. Dutch tests: RDW Open Data (CC0). Engine versions: EEA, monitoring of CO₂ emissions from new passenger cars (CC BY 4.0, DG CLIMA). Owner complaints: NHTSA ODI (public domain). Recalls: DVSA Vehicle Safety Branch Recalls Database, OGL v3.0. Brand and model names are trademarks of their owners and are used only to describe the vehicles. How we check the data →
Updated 29/10/2026